2012 Polo 1.2TSI turbo actuator faults

Started by typ53, August 19, 2023, 03:03:33 PM

Previous topic - Next topic

0 Members and 2 Guests are viewing this topic.

typ53

Had anyone experienced the EPC light/limp home mode fault on the 1.2TSI?

We've swapped the waste gate actuator and the fault went a way and then came back after 6 months.  Apparently there was a  service bulletin on this but I can't find any info on it. 

Looking for any advice on a repair please!

The Fleet:
Orange Roughy:'90 16v Corrado
'89 Carrera 4. 
'12 330d Touring
Still trying to figure out how to get 'em all to fit in a single garage....

GLIDN

the 1.2 and 1.4tdi are known for failing actuators. However, often goes hand in hand with the actual wastegate now being loose or damaged as well. So installing another second-hand unit could simply end up with the exact same results.

Ideally, you want to install a new actuator and test the wastegate to be free from damage. Otherwise, you'll need to replace the turbo and actuator for a cure. How long, depends if you installed a new or secondhand unit to your vehicle at the time of replacement.
Audi A4 DTM - K04 NZ New | All bolt-ons | Carbon Clean done
2012 MK6R Golf |Stage 3+ | Stage 4 DSG | Tuned & Built by HSP Tuning